One Brand. One Month. Want to Advertise on Smoke & Sear?

Find out how

Bavette Steak Pinwheels

Lee - Smoke & Sear
Servings: 4 Total Time: 2 hrs 30 mins Difficulty: Intermediate
Jump To Recipe Print Recipe
0 Add to Favorites
A delicious twist on bavette steak, perfect for BBQ enthusiasts.

Bavette, or flank steak, is a flavour-packed cut from the cow’s abdominal muscles. While it’s typically cooked hot and fast over coals, this recipe takes it to the next level. With a bit of prep and some tasty fillings, you’ll turn this steak into an impressive and delicious pinwheel. Let’s get rolling!

Bavette Steak Pinwheels

Prep Time 1 hr Cook Time 1 hr Rest Time 30 mins Total Time 2 hrs 30 mins
Beef
Print Recipe
Pin Recipe
0 Add to Favorites
Author: Lee - Smoke & Sear Cooking Method: , , Cuisine: Courses:
Difficulty: Intermediate Cooking Temp: 180  C Servings: 4 Estimated Cost: £ 20 Calories: Approximately 500 per serving Best Season: Suitable throughout the year

For the Steak

For the Filling

Instructions

  1. Prepare the Steak
    • Butterfly the Steak: Lay the bavette steak flat. With one hand on top, use a sharp knife to carefully cut through the middle of the steak, creating a butterfly effect. Leave about a 1cm edge intact.
    • Tenderize: Open the steak like a book and tenderize it using a meat mallet.
    • Season: Lightly season both sides with salt and pepper.
  2. Add the Filling
    • Layer: Start with a layer of spinach, followed by prosciutto and coppa. Top with thin sheets of Gouda cheese. Leave a 2cm edge all around.
    • Roll: Tightly roll the steak from bottom to top, ensuring the grain runs horizontally.
  3. Create the Pinwheels
    • Tie: Use butcher's twine to tie the rolled steak at 3cm intervals.
    • Skewer: Insert skewers through the roll, adjacent to each line of twine.
    • Slice: Cut into pinwheels between each line of twine.
  4. Cook the Pinwheels
    • Sear: Using a hot cast-iron skillet, sear the edges to create a crust and prevent the cheese from leaking out.
    • Grill: Place the pinwheels on the Kamado Joe grill with a deflector plate. Cook indirectly until the internal temperature reaches 135°F (57°C).
    • Rest: Remove from heat, loosely cover with foil, and let rest for 10 minutes before serving.

Equipment

Affiliate Disclosure: This post may contain affiliate links. If you buy a product using these links, we get a commission at no extra cost to you. Your support helps keep the BBQ magic alive, and we thank you in advance!

Note

  • Holding Temp: Keep the cooked pinwheels in a warm oven (about 60°C) until ready to serve to ease timing for a party.
  • Extra Flavour: Add a sprinkle of chili flakes to the filling for a bit of heat.
Keywords: bavette steak, pinwheel steak, BBQ recipe, grilling, flank steak, stuffed steak
Lee Bishop - Smoke & Sear

smoke.sear

919 19,425

Today at 10:28am (Tuesday 22nd April 2025) I witnessed the best @typhoondisplayteam of the year — 100% the best I’ve seen!

Squadron Leader Nathan Shawyer absolutely smashed it over @rafconingsby

There I was . . . iPhone in one hand, Wren (the dog) strapped to my waist, being swarmed by flies (note to self: change aftershave), trying to capture the magic.

Worth every buzz and bite — turn your sound up and enjoy this beauty!

P.S. Don’t worry, the dog you can hear barking in the video occasionally wasn’t Wren . . .

Others had come out to watch the display with their lovely dogs too — one clearly less keen on the noise from the jets haha.

105 10
Open
Today at 10:28am (Tuesday 22nd April 2025) I witnessed the best @typhoondisplayteam of the year — 100% the best I’ve seen! Squadron Leader Nathan Shawyer absolutely smashed it over @rafconingsby There I was . . . iPhone in one hand, Wren (the dog) strapped to my waist, being swarmed by flies (note to self: change aftershave), trying to capture the magic. Worth every buzz and bite — turn your sound up and enjoy this beauty! P.S. Don’t worry, the dog you can hear barking in the video occasionally wasn’t Wren . . . Others had come out to watch the display with their lovely dogs too — one clearly less keen on the noise from the jets haha.

When the kids ask for smashburgers . . . who am I to argue?
And being kids, they like ’em just so. No greenery in sight – ha!

Toasted @stpierreuk brioche buns, a slather of @angusandoink Comeback sauce, double smash patties with properly melted cheese, topped off with our own bacon jam – made fresh, same way every single time. A proper house favourite. Bit of crispy onions on top and that’s it. Simple. Smashy. And they all leave with full bellies and big smiles – that’s what it’s all about.

All cooked on the mighty @blackstoneproducts griddle, and yep . . . even air-fried the chips while making the jam and burgers. We don’t mess about.

#smashburger #blackstonegriddle #familyfavourite #bbqfamily #baconjam #doublecheese #blackstonecooking #ukbbq #stpierreuk

125 22
Open
When the kids ask for smashburgers . . . who am I to argue? And being kids, they like ’em just so. No greenery in sight – ha! Toasted @stpierreuk brioche buns, a slather of @angusandoink Comeback sauce, double smash patties with properly melted cheese, topped off with our own bacon jam – made fresh, same way every single time. A proper house favourite. Bit of crispy onions on top and that’s it. Simple. Smashy. And they all leave with full bellies and big smiles – that’s what it’s all about. All cooked on the mighty @blackstoneproducts griddle, and yep . . . even air-fried the chips while making the jam and burgers. We don’t mess about. #smashburger #blackstonegriddle #familyfavourite #bbqfamily #baconjam #doublecheese #blackstonecooking #ukbbq #stpierreuk

First cook on the new Blackstone – had to break it in with a kid-friendly Full English!

Went with the classics: sausages, hash browns, bacon, beans, fried eggs, griddled tomatoes, fried bread and of course… potato waffles (because kids).

Set the Blackstone up with different zones for each bit – sausages and waffles in the hotter section, eggs and bread on the low zone. Used the integrated air fryer basket for the hash browns and the warm drawer came in clutch for holding bits while the rest cooked.

Cooking on the Blackstone is FAST.

You’ve got to juggle it all a bit, but it’s mad satisfying once you get into the rhythm. This wasn’t a fancy cook – just a proper hearty breakfast to get used to the griddle.

The kids? They rated it 10,000,000 out of 10, which either means I’m a breakfast legend or they need a maths lesson.

Either way, I’ll take it.

Plenty more cooks coming – this was just the start.

#BlackstoneGriddleUK #FullEnglishOnTheGriddle #BBQBreakfast #BlackstoneCooking #FamilyBBQVibes

124 35
Open
First cook on the new Blackstone – had to break it in with a kid-friendly Full English! Went with the classics: sausages, hash browns, bacon, beans, fried eggs, griddled tomatoes, fried bread and of course… potato waffles (because kids). Set the Blackstone up with different zones for each bit – sausages and waffles in the hotter section, eggs and bread on the low zone. Used the integrated air fryer basket for the hash browns and the warm drawer came in clutch for holding bits while the rest cooked. Cooking on the Blackstone is FAST. You’ve got to juggle it all a bit, but it’s mad satisfying once you get into the rhythm. This wasn’t a fancy cook – just a proper hearty breakfast to get used to the griddle. The kids? They rated it 10,000,000 out of 10, which either means I’m a breakfast legend or they need a maths lesson. Either way, I’ll take it. Plenty more cooks coming – this was just the start. #BlackstoneGriddleUK #FullEnglishOnTheGriddle #BBQBreakfast #BlackstoneCooking #FamilyBBQVibes

🍍🔥 Pineapple Express Pulled Pork — with shatter-crisp crackling so savage, you’ll hear it from three streets over.

Massive love to @villagebutchers for sending me this absolute unit of a pork leg (9kg of bone-in, rind-on beauty). Injected it with pineapple rum, spun it low ‘n slow on the rotisserie, then crowned it with crispy shards of crackling like some kind of BBQ king 👑

Cooked this beast on the @everdurebyhestonblumenthal Hub 2 — first time I’ve fired it up in ages. Truth be told, I was sent it back in May 2023 to review . . . but with the house move, life chaos and all that jazz, it’s been sat in the garage gathering dust. Good job I kept hold of it — it’s the only kit I own that could handle the sheer size and weight of this bad boy.

Wanna try it yourself? Full step-by-step recipe is live now:

👉 https://www.smokeandsear.world/BBQ-recipes/pineapple-express-pulled-pork-with-shatter-crisp-crackling/

#SmokeAndSear #PineappleExpressPulledPork #CracklingKings #RotisserieLife #BBQUK #EverdureHub2 #PulledPorkPerfection #OutdoorCooking #PineappleBBQ #BBQCrackling #BBQMad #MeatMatters #VillageButchers #BackyardBBQ #LowAndSlow #BBQGoals #BBQRecipe

122 26
Open
🍍🔥 Pineapple Express Pulled Pork — with shatter-crisp crackling so savage, you’ll hear it from three streets over. Massive love to @villagebutchers for sending me this absolute unit of a pork leg (9kg of bone-in, rind-on beauty). Injected it with pineapple rum, spun it low ‘n slow on the rotisserie, then crowned it with crispy shards of crackling like some kind of BBQ king 👑 Cooked this beast on the @everdurebyhestonblumenthal Hub 2 — first time I’ve fired it up in ages. Truth be told, I was sent it back in May 2023 to review . . . but with the house move, life chaos and all that jazz, it’s been sat in the garage gathering dust. Good job I kept hold of it — it’s the only kit I own that could handle the sheer size and weight of this bad boy. Wanna try it yourself? Full step-by-step recipe is live now: 👉 https://www.smokeandsear.world/BBQ-recipes/pineapple-express-pulled-pork-with-shatter-crisp-crackling/ #SmokeAndSear #PineappleExpressPulledPork #CracklingKings #RotisserieLife #BBQUK #EverdureHub2 #PulledPorkPerfection #OutdoorCooking #PineappleBBQ #BBQCrackling #BBQMad #MeatMatters #VillageButchers #BackyardBBQ #LowAndSlow #BBQGoals #BBQRecipe